Green Synthesis of Selenium Nanoparticles using Green Coffee Beans: An Optimization Study.

In this study, ultrasonication extraction of some bioactive compounds from green coffee beans was optimized with the response surface method using Box-Behnken experimental design. The best condition was selected as 90.90 W ultrasonic power, 33.63 min sonication time and 30 % solid concentration. The responses obtained under optimum conditions had TPC, DPPH and CUPRAC values identified as 6603.33±2025.94 ppm GAE, 9638.31±372.17 ppm TE and 98.83 mmol, respectively. Microwave-assisted selenium nanoparticle production was carried out using the extract obtained under optimized conditions. The produced selenium nanoparticles showed absorbance between 350-400 nm. The surface morphology and size of the nanoparticles were determined by transmission electron microscopy (TEM) and spherical nanoparticles of about 100 nm were produced. Functional groups affecting the reduction were determined by FTIR analysis. In addition, the produced selenium nanoparticles had amorphous (non-uniform) structure and could maintain their stability at high temperatures.

Ultrasound-assisted deep eutectic solvent extraction of bioactive compounds from persimmon calyx.

This study aimed to investigate the ultrasound-assisted extraction of bioactive compounds from persimmon (Diospyros kaki) calyx by deep eutectic solvents (DES) with different molar ratios. For this reason, the prepared DES extracts' total phenolic-flavonoid compounds and antioxidant activities (1,1-diphenyl-2-picrilhydrazyl radical scavenging activity [DPPH•], Cupric Reducing Antioxidant Capacity (CUPRAC), and ferric reducing antioxidant power [FRAP]) were investigated as a result of the experimental design and optimization study conducted for this purpose. A sonication time of 20 min was determined as the optimal condition. Under these conditions, a molar ratio of 1.9:1 (lactic acid:choline chloride) and a water ratio of 70% provided the highest phenolic/flavonoid compounds and antioxidative activity. Correlations among water ratio, molar ratio, and sonication time were determined using principal component analysis (PCA). In conditions where total flavonoid compound, FRAP, and DPPH• are high due to PCA, it can be concluded that the sonication time is at high level; on the contrary, the water and molar ratios are at low level. In conclusion, ultrasound-assisted extraction using DES proved effective in persimmon calyx. Therefore, it can be recommended to use these environmentally friendly green solvents as an alternative to organic solvents in preparing extracts in various fields. PRACTICAL APPLICATION: This study shows the effectiveness of the ultrasound-assisted green extraction method using persimmon calyx specified as waste. These findings are compelling in the food industry in terms of consumers being now aware of green technology and the discovery that calyx is a good source of bioactive compounds.

Optimization of ultrasonic-assisted osmotic dehydration as a pretreatment for microwave drying of beetroot (Beta vulgaris).

The aim of this study was to optimize drying conditions during ultrasonic-assisted osmotic dehydration and subsequent microwave drying of red beetroot using the Box-Behnken design. For this purpose, ultrasonic-assisted osmotic dehydration was performed at different ultrasonic powers (50, 75, and 100 W), sonication times (20, 40, and 60 min), and salt concentrations (0%, 15%, and 30%). The subsequent drying procedures were conducted with 231, 518, and 805 W microwave power. The best condition was selected as 5.15% salt concentration, 20 min sonication time, 50 W ultrasonic power, and 716.45 W microwave power. The responses obtained under optimum conditions were determined as 68.06%, 9.54 mg GAE/g dm, 28.23, 42.66, and 3.08 for DPPH• % inhibition, total phenolic content, L*, a*, and b* values, respectively. While favorable impacts on color were detected for the applied pretreatments, the DPPH• scavenging activities of the dried beetroot were determined to be more significant after ultrasonic-assisted osmotic dehydration. Furthermore, the drying kinetics of beetroot were evaluated according to the Midilli et al. model. When the fit to the model was investigated, it was compatible at R2 > 0.90 level. As a result, the ultrasonic-assisted osmotic dehydration pretreatment performed before the microwave drying method preserved the quality characteristics of beetroot samples and was successfully applied.

Impact of ultrasonication applications on color profile of foods.

Food color is a feature that provides preliminary information about their preference or consumption. There are dominant pigments that determine the color of each food; the most important pigments are anthocyanins (red-purple color), chlorophylls (green color), carotenoids (yellow-orange color), and betalains (red color). These pigments can be easily affected by temperature, light, oxygen, or pH, thereby altering their properties. Therefore, while processing, it is necessary to prevent the deterioration of these pigments to the maximum possible extent. Ultrasonication, which is one of the emerging non-thermal methods, has multidimensional applications in the food industry. The present review collates information on various aspects of ultrasonication technology, its mechanism of action, influencing factors, and the competence of different ultrasonication applications (drying, irradiation, extraction, pasteurization, cooking, tempering, etc.) in preserving the color of food. It was concluded that ultrasonication treatments provide low-temperature processing at a short time, which positively influences the color properties. However, selecting optimum ultrasonic processing conditions (frequency, power, time, etc.) is crucial for each food to obtain the best color. The key challenges and limitations of the technique and possible future applications are also covered in the paper, serving as a touchstone for further research in this area.

Changes of some bioactive and physicochemical properties during the black tea processing.

In this research, some physical and bioactive properties of tea samples collected from every processing stage of black tea production were investigated. The processing stages were significantly effective on the investigated properties (moisture content, color parameters [L* , a* , and b* ], and pH values the total phenolic substance, antioxidant activity) (p < 0.01). The antioxidant activities were found to be at a high level in fresh tea but decreased during the processing stages. Furthermore, the lowest activity was observed in the drying stage for extracts prepared with water and in the drying and sorting stages for extracts prepared with ethanol. In addition, it was determined that palmitic acid, myristic acid, and capric acid as saturated fatty acids, oleic acid, heptadecenoic acid, and eicosenoic acid as unsaturated fatty acids formed the fatty acid profile. Palmitic acid was determined to be the dominant fatty acid in tea samples. PRACTICAL APPLICATION: Tea is a beverage known to have positive health effects. The chemical structure of tea is very effective in providing these positive effects on health. Black tea production takes place in five stages in general terms (withering, rolling, oxidation, drying, and sorting stages) after the harvesting. These processes are very effective in the quality properties of tea. This research provides information about effects of processing stages on black tea. Our results demonstrate that processing was significantly effective on the physicochemical and bioactive properties of tea. Functionality of bioactive compounds could be maintained by optimization of the applied processes.

Functional and technological characterization of lactic acid bacteria isolated from Turkish dry-fermented sausage (sucuk).

In this study, 10 lactic acid bacteria were isolated from Turkish fermented sausage (sucuk) and identified as 5 Lactobacillus plantarum, 1 Pediococcus acidilactici, 1 Weissella hellenica, 1 Lactobacillus pentosus, and 2 Lactobacillus sakei. PCR screening of genes encoding plantaricin A and pediocin showed the presence of plantaricin A gene in 9 and pediocin gene in 3 of strains. All isolates showed antibacterial and antifungal effect on most of the tested microorganisms. gad gene, encoding glutamic acid decarboxylase enzyme, was detected in all isolates except Weisella hellenica KS-24. Eight of isolates were determined as gamma-amino butyric acid (GABA) producer in the presence of 53 mM mono sodium glutamate (MSG) by HPLC and TLC analysis. DPPH scavenging activity was observed for all isolates. Additionally, isolates were able to produce exopolysaccharide in the presence of sucrose. The best exopolysaccharide (EPS) production was achieved with L. plantarum KS-11 and L. pentosus KS-27. As a result, this study characterized some techno-functional properties of LAB isolates from sucuk. It was concluded that the isolates studied have the potential to be used in obtaining functional products in meat industry, as well as strain selection may be effective in providing the desired properties in the product.

Impact of different microwave treatments on food texture.

Electromagnetic waves are frequently used for food processing with commercial or domestic type microwave ovens at present. Microwaves cause molecular movement by the migration of ionic particles or rotation of dipolar particles. Considering the potential applications of microwave technique in food industry, it is seen that microwaves have many advantages such as saving time, better final product quality (more taste, color, and nutritional value), and rapid heat generation. Although microwave treatment used for food processing with developing technologies have a positive effect in terms of time, energy, or nutrient value, it is also very important to what extent they affect the textural properties of the food that they apply to. For this purpose, in this study, it has been investigated that the effects of commonly used microwave treatments such as drying, heating, baking, cooking, thawing, toasting, blanching, frying, and sterilization on the textural properties of food. In addition, this study has also covered the challenges of microwave treatments and future work. In conclusion, microwave treatments cause energy saving due to a short processing time. Therefore, it can be said that it affects the textural properties positively. However, it is important that the microwave processing conditions used are chosen appropriately for each food material.

Technological properties of autochthonous Lactobacillus plantarum strains isolated from sucuk (Turkish dry-fermented sausage).

PURPOSE: Five Lactobacillus strains isolated from sucuk (Turkish dry-fermented sausage) were studied for their genetic and technological properties. METHODS: For genotypic identification, strains 16S rRNA gene sequences were used. To determine the antimicrobial activity of strains, seven foodborne pathogens were tested. Strains technological properties were characterized. RESULTS: These strains were identified as Lactobacillus plantarum by 16S rRNA gene sequence analysis and the phylogenetic tree obtained by neighbor-joining method allowed grouping of these strains into three subgroups. L. plantarum strains showed antagonistic activities against Staphylococcus aureus, Listeria monocytogenes, Bacillus cereus, and Micrococcus luteus strains. PCR assay, using specific primers, showed the presence of bacteriocin (plantaricin) encoding genes in all L. plantarum strains tested. Antimicrobial metabolite production of these strains started at log phase and reached the maximum level at the end of the stationary phase. Regarding their technological properties, better growth was observed at 25 °C compared with 15 °C and 45 °C. The isolates which grown well within the pH scale pH 4.5-6.5 range additionally showed a decent growth at 6.5% salt concentration. It has been found that strains do not exhibit lipolytic and proteolytic activities nor have lysine, ornithine, and arginine decarboxylase activity. On the other hand, one strain showed weak nitrate reductase activity, and four strains produced acetoin from glucose. In addition, all strains were DL-lactic acid producers. Consequently, L. plantarum strains isolated exhibited some biochemical properties required for a starter culture in sucuk and similar products. CONCLUSIONS: All identified strains may be a protective culture in the production of fermented meat products. In particular, L. plantarum S51 was distinguished from other isolates due to the inability to form acetoin from glucose. Further work will be needed to characterize L. plantarum strains as starter culture.